Electric Trunk Lift Kit Aftermarket Tailgate Retrofit Smart Kick Sensor for DFSK Glory 580 Pro Fengon 580 Pro
Trading Properties
Basic Properties
Mr. Wong
- +86 190 6808 0629 Contact Us
| Voltage: | 12V DC | Peak Current: | 8A Per Set |
| Quiescent Current: | Below 0.1A | Travel Time: | About 8 Seconds |
| Sealing: | IP54 | Temperature Range: | -30°C To +70°C |
| Cycle Life: | 50,000 Operations | Set Weight: | 5.0 Kg |
| Actuators: | Two Geared Struts, Sealed Housing | Material: | Sealed Geared Strut, Zinc-coated Bracket, ABS Controller |
| High Light: | Auto Open Trunk Kick Access,Automatic Tail Gate Lift,Electric Car Trunk Soft Close |
||
Electric Trunk Lift Kit for DFSK Glory 580 Pro / Fengon 580 Pro
The 580 Pro trims brought a sharper front end and a more premium cabin, yet the boot still asks for a manual pull every time. This kit closes that gap. Two motorised actuators take the place of the gas springs, a controller reads the existing latch signals, and the driver gains remote, cabin and hands-free access. Every fixing point already exists on the car; nothing is cut, welded or painted, so the modification can be removed without leaving a mark.
How the Pro Body Differs
Compared with the standard 580, the Pro uses a different upper hinge stamping and a slightly longer spring. Our kit therefore ships with a dedicated bracket pair and an actuator matched to that travel. Buyers who are unsure of the body variant can send a photo of the hinge area and we will confirm before dispatch; the correct bracket set is included at no extra cost either way.
Key Benefits
- Three ways to open and close: factory remote, supplied cabin button, or a foot sweep under the bumper.
- Gentle acceleration, constant-speed travel and a cushioned landing, so the latch is guided rather than slammed.
- Obstruction detection reverses the panel instantly, protecting hands, pets and cargo.
- Two stored open heights suit basement garages, car washes and low canopies.
- Commands are blocked unless the gear selector is in P, preventing movement while driving.
- Manual operation stays available whenever power is off.
- Sleep mode cuts draw below 0.1A after half a minute of inactivity.
Technical Data
| Item | Value |
|---|---|
| Fitment | DFSK Glory 580 Pro / Dongfeng Fengguang Fengon 580 Pro |
| Supply voltage | 12V DC |
| Actuators | Two geared struts, sealed housing |
| Travel time | About 8 seconds |
| Peak current | 8A per set |
| Quiescent current | Below 0.1A |
| Sealing | IP54 |
| Temperature range | -30 C to +70 C |
| Cycle life | 50,000 operations tested |
| Set weight | 5.0 kg |
| Warranty | 24 months |
Installation Checklist
- Battery negative lead disconnected before any trim work.
- Factory struts removed and stored with the vehicle file.
- Pro bracket pair bolted to body and tailgate studs, torque per supplied card.
- Powered actuators clipped in and harness routed along the original loom path.
- Controller mounted in the rear quarter, plugs engaged until they click.
- Cabin switch fitted, foot sensor bracket aligned with the bumper centre line.
- Trim refitted, power restored, two learning cycles completed.
- Height limit stored and function tested from all three trigger points.
A technician working alone finishes the list in around 90 minutes. A second car of the same model typically takes an hour.
Quality Gates
Every set passes a bench routine before boxing: actuator load, stroke timing, latch handshake, reversal force, sensor threshold and a visual check of the fastener bags. Brackets receive a zinc coating rated for humid coastal climates, harness terminals are crimped and pull-tested, and controllers are flashed with firmware for the 580 Pro stroke length only, so no field reconfiguration is needed.
Supply
Evaluation orders from one set. Bulk lead time 8 to 18 working days, stock dispatch within 5 days when available. Cartons hold one set at 79 x 21 x 19 cm or two sets at 82 x 25 x 36 cm, foam lined and moisture protected. Air, sea and express forwarding supported. OEM carton, manual and label printing from 200 sets. Fitting questions answered in English within one working day.